"Major Service- 83-93"

This service is to be done at 15,000 mile or 12 month intervals beginning at 15,000 miles


Undercarriage
  • Change oil and oil filter.
  • Check manual transmission oil (add oil if required).
  • Change automatic transmission oil and strainer (transmission model 4HP22 through 1991 only, to concide with Inspection I, invoiced separately).
  • Check rear axle oil level (add oil if required).
  • Check fuel tank lines and connections for leaks.
  • Check condition, position and mounting of exhaust system. Examine for leaks.
  • Check brakes: thickness of pads and drums (lining remaining, % front ____; % rear_______). Inspect brake cylinders and dust boots for leaks. Check and adjust parking brake. Check brake system connections and lines for leaks, damage, and incorrect positioning. Grease wheel centering hubs.
  • Check condition of suspension track rods, front axle joints, steering linkage, and joint disc.
  • Check tire pressure and tread wear.
  • Check tension and condition of V-belts.
Engine Compartment
  • Replace air filter.
  • Check valve clearances and adjust if necessary.
  • Change spark plugs.
  • Check compression:
  • Replace fuel filter.
  • Check cooling system and all connections and heater hoses for leaks. Check coolant level (add coolant if required). [see annual check].
  • Check steering gear or power steering for leaks and correct oil level.
  • Check brake and clutch fluid (add fluid if necessary). [see anual check]
  • Check windshield washer fluids.
  • Check ground connection for SRS front-sensor screws to body.
  • Check battery electrolyte level and add distilled water as required.
  • Tighten A/C compressor mount bolts.
  • Check air conditioner for operation and proper Freon charge.
  • Clean and lubricate bearing points and moving parts of the throttle butterfly linkage.
Body Electrical
  • Check steering for absence of play in straight ahead position. Adjust if necessary (invoiced separately).
  • Check operation of wipers and washer system:blades, washers and jet position.
  • Check condition and function of seat belts.
  • Tighten nuts and bolts for door locks and striker plates.
  • Oil hinges of doors, hood, and lid; grease hood and lid catches, door catches and striker plates. Check operation of each component.
  • Self-leveling suspension:check oil level with vehicle unloaded (add oil as required)
  • Check lighting:headlights, parking, back-up, license plate, interior, glove box, map lights, sun visor, engine and luggage compartment light. Align headlights if necessary.
  • Warning equipment: turn signals, hazard flashers, brake lights, brake lining, brake fluid level, battery, transmission display range, "check engine" light, horns, headlight dimmer and flasher switch, check control panel operation ABS (anti-lock braking) and SRS (airbag) warning lights.
  • Check instrument lighting, control lighting.
  • Check heater and A/C blowers, rear window defroster.
  • Check rear view mirror.
  • Lubricate slide rails on sunroof.
  • Road Test.
  • Read out diagnostic systems. Check oxygen sensor output and response.
  • Reset service indicator.
  • Stamp service book_____(no service book found____).
  • Check emission levels:_____% CO at idle ______ ppm HC at idle.
Recommended Services (Invoiced Separately)
  • Rotate balance all 4 wheels and tires.
  • Service automatice transmission (including filter screen oil, and gasket).
Inspection II

This service is to be done in addition to the Inspection I service at 30,000 mile intervals beginning with 30,000
Undercarriage
  • Check clutch driving plate for wear.
  • Change manual transmission oil.
  • Change automatic transmission fluid (A4S 310-type automatic transmission 1992 > only)
  • Check oil in rear axle.
  • Half-shafts:check for leaks at flexible boots.
  • Rear disc brakes:check thickness of parking brake linings.
  • Check front wheel bearing play.
Engine
  • Check automatic transmission oil (add if necessary).
  • Check and adjust drive belt tension (M20 engine).
  • Every five years or 50,000 miles (whichever comes first).
  • Change timing belt (M20 engine only). Invoice separately.
Annual Check
  • Change brake fluid.
  • Check operation of master cylinder and servo, and inspect for leaks.
  • Inspect body for rust (Warranty Inspection).
  • Check and adjust headlights and auxiliary driving lights.
  • Check steering:lock angle limits, threaded connections, power assistance.
  • Change coolant every two years.
Emission Control Service
  • Replace oxygen sensor every 30,000 or 50,000 miles as specified.
"Minor Service"