"Major Service - 91" This service is to be done at 15,000 mile intervals beginning at 15,000 miles. Undercarriage Change oil filter. Check manual transmission oil (add oil if required). Change automatic transmission oil and strainer (4HP22 FA Transmission, invoiced separately). Check torque of front subframe bolts. Check for tightness of air conditioning mount bolts (318i/M70). Check rear axle oil level (add oil if required). Check fuel tank lines and connections for leaks. Check condition, position and mounting of exhaust system. Examine for leaks. Check brakes: thickness of pads and drums. Inspect brake cylinders and dust boots for leaks. Check and adjust parking brake. Check brake system connections and lines for leaks, damage, and incorrect positioning. Grease wheel centering hubs. Check condition of suspension track rods, front axle joints, steering linkage, and joint disc. Check tire pressure and tread wear. Engine Compartment Download diagnostic codes. Replace air filter (recommended in California). Replace fuel filter (recommended in California). Check cooling system and all connections and heater hoses for leaks. Check coolant level (add coolant if required). [see annual check]. Check steering gear or power steering for leaks and correct oil level. Check brake and clutch fluid (add fluid if necessary). [see annual check] Check windshield washer fluids. Check ground connection for SRS (airbag) front-sensor screws to body. Check battery electrolyte level and add distilled as required. Tighten A/C compressor mount bolts. Check air conditioner for operation and proper Freon charge. Clean and lubricate bearing points and moving parts of the throttle butterfly linkage. Body Electrical Check steering for absence of play in straight ahead position. Adjust if necessary (invoiced separately). Check operation of wipers and washer system:blades, washers and jet position. Check condition and function of seat belts. Tighten nuts and bolts for door locks and striker plates. Oil hinges of doors, hood, and lid; grease hood and lid catches, door catches and striker plates. Check operation of each component. Self-leveling suspension:check oil level with vehicle unloaded (add oil as required) Check lighting:headlights, parking, back-up, license plate, interior, glove box, map lights, sun visor, engine and luggage compartment light. Align headlights if necessary. Warning equipment: turn signals, hazard flashers, brake lights, brake lining, brake fluid level, battery, transmission display range, "check engine" light, horns, headlight dimmer and flasher switch, check control panel operation ABS (anti-lock braking) and SRS (airbag) warning lights. Check instrument lighting, control lighting. Check heater and A/C blowers, rear window defroster. Check rear view mirror. Lubricate slide rails on sunroof. Road Test. Read out diagnostic system. Reset service indicator. Stamp service book_____(no service book found____). Recommended Services (Invoiced Separately) Rotate balance all 4 wheels. Service automatice transmission (change oil only, per BMW). Inspection II This service is to be done in addition to the Inspection I service at 30,000 mile intervals beginning with 30,000 Undercarriage Replace main fuel filter. Check clutch driving plate for wear. Change manual transmission oil. Check oil in rear axle. Half-shafts:check for leaks at flexible boots. Rear disc brakes:check thickness of parking brake linings. Check front wheel bearing play. Engine Replace spark plugs. Check compression and record: cyl.# Check tension and condition of V-belts; if needed, replacement to be invoiced separately. Replace intake air cleaner filter element. Check automatic transmission oil (add oil if necessary). Annual Check Change brake fluid. Check operation of master cylinder and servo, and inspect for leaks. Inspect body for rust (Warranty Inspection). Check and adjust headlights and auxiliary driving lights. Check steering:lock angle limits, threaded connections, power assistance. Change coolant every two years . Emission Control Service Replace oxygen sensor every 50,000 miles. "Minor Service" This service is to be done every 15,000 miles beginning at 7,500 miles, alternating with the Inspection I or Inspection II (major services). Engine Oil and Filter: Change while engine is operating temperature. Cooling hoses/Coolant: Check for pressure tightness and coolant level/concentration. Fuel Lines: Check for pressure tightness and integrity. Reset: service indicator. Additional Services Performed Steering:Check steering box, steering linkage, joint disc, threaded connections, tightness and oil level. Brakes:Check brake pads and discs (remove and reinstall wheels), check level of brake and clutch fluid in reservoir; add fluid if required. Check brake hoses and connections for leaks and distortion. Parking Brake: Check and adjust parking brake cables. Tires: Check all tires (including spare tire) for tread pattern and pressure. Adjust if necessary. Illumination: Check headlights, parking, backup, license plate, interior, glove box, map reading lights (front/rear), illuminated sun visor, engine and luggage compartment lights, turn signal, hazard warning flashers, brake lights, horns, headlight dimmer and flasher switch. Check Control panel operation, instrument lighting, control lighting, ABS (antilock braking) and SRS (airbag) lights. Headlights: and headlight alignment (adjust if necessary). Windshield Wipers, Washers: adjust washer jet position if necessary; check level and fluid antifreeze protection in reservoir. Check intensive washer fluid level: add as required. Seatbelts: Check for condition and correct operation. Cassette/Radio:Clean tape head, capstan, and pinch rollers every 50-100 hours of operation or earlier if quality of sound is impaired. Road Test:for vehicle operation and safety items. Stamp Service Book:______(no service book found_____). Annual Services(to be invoiced separately) Hydraulic Fluid:Change yearly. Coolant: Change every other year. Emission Control Service(to be invoiced separately) Replace Oxygen Sensor:Every 50,000 miles.